(Bloomberg) — Boeing Co. is preparing to bolster the long-term safety of its troubled 737 Max with technology borrowed from space vehicles and urban drones that can provide data to help back up its sensors.
The system — known as synthetic air data — takes existing information on the aircraft, runs it through a computer program and produces readings that mimic what costly additional sensors provide.
A Boeing Co. 737 Max airplane at the company’s manufacturing facility in Renton, Washington.
Photographer: David Ryder/Bloomberg
Added as a result of pressure from overseas regulators, it would reduce the risk of accidents such as those on the Max. But it would also address a wide range of deadly air crashes triggered by confusing cockpit readings, according to engineers and academic research. It’s already proved its value on Boeing’s 787, and Airbus SE is adopting similar techniques in its aircraft.
“The reason why myself and a bunch of others are looking at it is it does have the promise to enhance safety,” said Demoz Gebre-Egziabher, an aerospace engineering professor at the University of Minnesota who is researching such systems.
At the same time, Gebre-Egziabher and others caution the technology involves knotty challenges, and it’s most likely not something Boeing can slap on the Max in a few months. “The algorithms are complicated and certifying them is a bear,” Gebre-Egziabher said.
Boeing’s best-selling plane, an updated version of the decades-old 737 family, was grounded in March 2019 after the second of two crashes in less than five left 346 dead. The chain of events leading to both crashes was prompted by the failure of sensors known as angle-of-attack vanes, and the new technology would provide redundancy for those readings without adding additional sensors, which are costly.
Earlier: Boeing Given Long List of Proposed Fixes for 737 Max Return
U.S. aviation regulators earlier this month said they’ve tentatively accepted Boeing’s sweeping redesign of the Max without the new technology, meaning the plane could be approved to fly again as soon as this fall. The fixes also meet the standards of other nations, the Federal Aviation Administration said.
The new suite of virtual sensors Boeing is planning to add to the plane is a result of demands by the European Aviation Safety Agency, which has repeatedly said it wants even more protections for the Max.
In a compromise, EASA has agreed not to hold up the plane’s recertification, but the agency, along with the FAA, is insisting that Boeing make future improvements and spell out how the company plans to do so before final approval, said a person familiar with the deliberations who wasn’t permitted to talk about them publicly.
Specifically, EASA wants more backups for the angle-of-attack vanes. The Max, like other Boeing aircraft, has two angle-of-attack sensors, while Airbus planes have three.
Read More: Boeing 737 Max Return Outside U.S. Seen Slowed by Regulators
Discussions on the issues are still underway at EASA and the agency can’t comment, it said in a statement.
Despite the differences in sensors, Airbus and Boeing models have nearly identical accident rates, which overall are at all-time lows. But both manufacturers have suffered incidents and accidents as a result of angle-of-attack failures.
Even with the fixes to the Max, a single angle-of-attack sensor failure can trigger multiple confusing alarms in the cockpit. Adding a third such sensor — a small wind vane that measures whether the jet’s nose is pointed above or below the oncoming air — could help mitigate that, European regulators have said. Such an addition would be costly and time consuming, though.
However, breakthroughs in recent decades have made it possible to produce accurate estimates of angle of attack without a new sensor, Gebre-Egziabher said. These systems can also replicate a plane’s speed and other flight data, according to academic research and uses on existing aircraft.
Improvements in motion detectors — highly sophisticated cousins of the devices in smartphones that measure how many steps you’ve taken — can monitor a plane’s dips and turns. GPS position data helps ensure accuracy. And modern computers allow the data to be knit together using physics formulas to show speed and how the plane is behaving, including its angle of attack.
Peter Lemme, a consultant who worked on aircraft control systems for earlier Boeing models, cautioned that such systems remain notoriously complex.
“It’s easy to talk about but it’s hard to do,” Lemme said. “This is not a casual undertaking. It will probably take at least two years.”
Not only must engineers ensure that the formulas they devise work in every scenario imaginable, but aviation software must be many times more reliable than in consumer products.
Adopting such a system also comes with controversy. A Boeing engineer last year filed an ethics complaint with the company charging his efforts to add synthetic readings to the Max during its development were blocked by managers opposed to the cost and complexity, according to a letter he wrote to Senate investigators.
Boeing said in a statement it doesn’t comment on internal complaints from its employees. The company has also declined to comment on its work to add synthetic sensors to the Max, other than to say, “We continue to make steady progress towards safely returning the airplane to service.”
While creating such systems can be difficult, their value has already been demonstrated. They’ve been used to help guide NASA spacecraft re-entering the atmosphere, and Airbus recently patented a design for such systems.
One of the most promising areas for synthetic air-data systems is in drones, Gebre-Egziabher said. These vehicles need the equivalent of additional sensors to become safe enough for routine flights over urban areas. But they’re more sensitive to weight, so adding multiple physical sensors isn’t viable.
Boeing added a synthetic system to its 787, the long-range plane introduced in 2011. Airbus uses at least some of the technology on its A350.
A 2015 incident on a Jetstar Airways 787 flying from Melbourne to Singapore illustrates its potential benefits. The jet’s three external sensors used to compute speed all iced up simultaneously, according to a report by the Australian Transport Safety Bureau.
Such failures have been a vexing problem in aviation because the sensors are all subject to the same problem — ice. The glitches can lead to confusion in the cockpit and in rare instances they’ve triggered crashes, such as when an Air France Airbus A330 went down in the Atlantic Ocean in 2009, killing all 228 aboard.
In the Jetstar Airways case, however, the plane’s synthetic system — which is immune from ice — recognized that the three sensors had failed and helped trigger alarms to the crew, investigators said.
For more articles like this, please visit us at bloomberg.com
©2020 Bloomberg L.P.